BMW E36 Coupe Installationshandbuch PDF herunterladen (Seite 7)

BMW E36 OEM POWER REAR VENT WINDOW INSTALL

June 2007 Jeremy Reyna

jjreyna@sbcglobal.net

reservoirandhavefullaccesstothefusebox.Thereisathirdredwireontheoutsideof

thebox,butIleftitattached.

5.9.4 Insidethecar,underdriver’sdashfoldbackthecarpetthatnormallysupportsthedead

pedal.

5.9.5 Nextremovethefour7mmboltsmount

ingthefuseboxtothefirewall.Intheengine,

lookingatthefusebox/firewall,youcanseethreeofthebolts(TR,BR,BL),thefourth

(TL)youwillnotsee.Insidethecar,theTRboltisseenthruacircularholeinthegray

insulationtotheleftan

dupoftheclutchpedal.TheBRboltisbehindthecarpetthat

supportsthedeadpedal.TheBLboltislocatedbehindthewirebundlerunningtoward

thefloorboardthatisbehindthedeadpedal.

5.9.6 BeforeremovingtheTLbolt,youhavetocleartheway.Onceyo

u’veremovedthefan

connector(asnotedabove)thereisanotherblackboxvisiblewhichblocksaccesstothe

TLbolt.Removethetwoplasticnutsanditdropsouteasily.

5.9.7 RemovetheTLbolt.Lookingbeyondtheblackboxyoujustremoved,youcan’tseethe

TLboltb/cit

’sbehindthegrayinsulation.Youwillneedtopunchaholeinthe

insulationtoaccesstheTLbolt.Iuseda14mmsocketattachedtoareallylongextension

topushthroughthegrayinsulation.IusedtheTRandBLboltlocationstoapproximate

whereIthoughttheTLboltwasloc

ated.ThenIpushedthe14mmsockettocutthruthe

insulation.Iwasabout1/3ofinchtoohigh,butitwasstillaccessible.

5.9.8 Onceyouremovealltheboltsyoucanslidethefuseboxtowardthefrontofcarjust

enoughtoloosenthefus

ebox‐to‐firewallpanel(Figure10).Notethatthepanelhasatie

wrapthatistiedtothewirebundle.Whenyoupulluponthepanel,theentirebundle

liftsup.Usecautionb/cIbrokemypaneltryingtopryitupandnotknowingab

outthe

tiewrap.Irecommendpullinguponthebundleorclippingtiewrapbeforepullingon

panel.Withthepanelremoved,youcaneasilypassthewiringharnessthroughthe

firewall.



Figure8–Removing4bolts(Item1)toreleaseFuseboxfromfirewall



1 2 3 4 5 6 7 8 9 10 11 12 ... 31 32

Keine Kommentare

BMW E36 Coupe Installationshandbuch Seite 7