BMW 2006 M5 Bedienungsanleitung PDF herunterladen

This Service Information bulletin supersedes S.I. B34 05 06 dated August 2006.

PERFORM THE PROCEDURE OUTLINED IN THIS SERVICE INFORMATION ON ALL AFFECTED

VEHICLES THE NEXT TIME THEY ARE IN THE SHOP FOR MAINTENANCE OR REPAIRS AND

PRIOR TO RETAIL DELIVERY.

SUBJECT

Service Action: Replace SZL Optical Element

MODEL

E60, E61 (5 Series)

E63, E64 (6 Series)

SITUATION

The optical sensor in the SZL (Steering Column Switch Sensor) may fail.

A defective optical steering angle sensor leads to failure of Active Steering, DSC (Dynamic Stability Control), ARS

(Active Roll Stabilization), AHL (Adaptive Headlights), ACC (Active Cruise Control) and the automatic turn signal

reset function.

The failure of DSC, ARS and Active Steering is indicated by indicator lamps and display messages.

Note: One or more systems may fail, depending on the degree of damage to the optical steering angle sensor.

This Service Action checks the SZL and replaces the optical element if necessary.

A copy of the customer notification letter is attached.

To minimize the customer's inconvenience caused by this Service Action, pick

up (and deliver after repair) the

affected vehicle from customer's home and provide appropriate alternative transportation.

Customers will be impressed when you return their cars cleaned inside and out and with a full tank of gas.

Reimbursement information for the vehicle fueling and valet costs may be found in the Warranty portion of this

bulletin.

AFFECTED VEHICLES

This Service Action involves E60, E61 (5 Series), E63, E64 (6 Series) vehicles, which were produced from August 26,

2005 to July 28, 2006.

In order to determine if a specific vehicle is affected by this Service Action, it will be necessary to utilize the "Service

Menu" of the DCS (Dealer Communication System). Based on the response of the system, either proceed with the

corrective action or take no further action.

The Chassis Number Ranges listed below are

only

for informational purposes and are not to be considered as the only

deciding factor.

SI B34 05 06

Brakes

September 2006

Technical Service

Model

Chassis Number Range

Page 1

10/3/2006

http://www.bmwtis.com/tsb/bulletins/bulletin_graphic_temp/B340506g.htm

1 2 3 4 5 6

Inhaltsverzeichnis

Seite 1 - AFFECTED VEHICLES

This Service Information bulletin supersedes S.I. B34 05 06 dated August 2006. PERFORM THE PROCEDURE OUTLINED IN THIS SERVICE INFORMATION ON ALL AFF

Seite 2 - PROCEDURE

PROCEDURE 1. Turn the steering wheel so that the front wheels are in the straight-ahead position 2. Follow the Repair Instructions RA 61 31 006 "

Seite 3

4. Remove the SZL control unit. 7. Locate a clean workplace for the repair. An anti-static mat MUST be used – see SI B04 19 04. Put on the disposable

Seite 4

gloves supplied in the parts set (only these gloves may be worn). THE UTMOST CLEANLINESS MUST BE ENSURED. 10. Install the new optical element. Incorre

Seite 5 - WARRANTY INFORMATION

14. Reinstall the SZL control unit. Important: The SZL must not be reinstalled until all four cover screws have been tightened correctly. 15. Vehicles

Seite 6 - ATTACHMENTS

REFUELING COST (VEHICLE ALREADY DELIVERED TO CUSTOMER) BMW of North America, LLC, will provide reimbursement to have the gas tank topped off once, as